Lockheed XV-4 Hummingbird

XV-4 Hummingbird
	First prototype XV-4 Hummingbird
Role	VTOL
Manufacturer	Lockheed
First flight	7 July 1962
Status	Both aircraft destroyed during testing
Primary user	United States Army
Number built	2

The Lockheed XV-4 Hummingbird (originally designated VZ-10) was a U.S. Army project to demonstrate the feasibility of using VTOL for a surveillance aircraft carrying target-acquisition and sensory equipment.^[1] It was designed and built by the Lockheed Corporation in the 1960s, one of many attempts to produce a V/STOL vertical take off/landing jet. Both prototype aircraft were destroyed in accidents.

Design and development[]

Vertical take-off lift was obtained by exhausting the engine flow downward through multiple nozzles, augmented by a secondary flow of cold air.^[1] But the performance was far below estimates with only a 1.04 thrust-to-weight ratio, and the prototype crashed on 10 June 1964, killing the pilot. The second aircraft was converted to lift jets instead, yet also crashed after several tests.

Rockwell's XFV-12 would be even less successful at producing lift by using engine exhaust to entrain cold air, in this case through flaps on the wings.

None of the early American V/STOL designs would result in a production aircraft. The British Hawker Siddeley Harrier used vectoring nozzles, while the Russian Yakovlev Yak-38 Forger attack jet used lift jets in conjunction with rotating rear nozzles. The Lockheed F-35 Lightning II would later employ a shaft-driven lift fan located in the fuselage.

Testing[]

The first conventional takeoff flight of the first prototype, XV-4A (62–4503), took place on 7 July 1962. Initial tethered flight tests were carried out on 30 November 1962 with the first free hovering flight occurring on 24 May 1963. The first flight to transition from hovering to forward flight took place on 8 November 1963. 62–4503 was destroyed in a fatal crash in Cobb County on 10 June 1964.

Lockheed modified the second prototype aircraft between 1966 and 1968 to XV-4B standard. The two Pratt & Whitney JT12 engines were replaced with six General Electric J85 turbojets, four of these units acting as lift jets. This aircraft crashed in Georgia on 14 March 1969; pilot Harlan J. Quamme escaped uninjured, using the ejection seat.

Variants[]

On 4 June 1968, the second prototype of the XV-4B Hummingbird rolled out. Just like the XV-4A, the XV-4B used vertical takeoff and landing systems (VTOL) as well as conventional flight methods. Upon takeoff the aircraft weighed 5706 kg. The wingspan was 7.8m, and it had a top speed of 883 km/h with a cruising speed of 630 km/h (.68 mach). It had a range of 965 km and was able to climb at a rate of 3660m/minute. The XV-4B was 10.36m long. The heaviest part of the plane was the propulsion system, which weighed in at 1466 kg. The initial service life of the aircraft was intended to be 500 hours, but the aircraft was destroyed in 1969 during testing, long before the designated goal. The fuel tanks were located internally, with boost pumps and jet ejectors, along with the associated valves. The tanks were located in the front of the fuselage and could hold a total of 740 gallons of aviation turbine fuel. Because of the forward position of the tanks, fuel had to be consumed evenly. An unbalance in the fuel tanks of over 100 gallons ran the risk of destabilizing the aircraft.

The XV-4B was significantly different than the XV-4A in its internal design. The differences were found in the wings, fuselage, landing gear, power plant installations, hydraulics and controls. XV-4B contained two reaction control valves as a failsafe for the engine. One major change was the addition of 4 turbo jet engines faced vertically on the fuselage. This provided massive amounts of vertical thrust for VTOL flight. The addition of a stability augmentation system (SAS), along with hydro-mechanical clutches and feel springs, gave the pilot a good feel on the controls and more ability to control the SAS. The rudder included a new centering spring above the feel spring to reduce friction on the rudder. The Primary Flight Control System (PFCS) was a hybrid fly-by-wire system along with conventional flight controls as a backup. No fuel was carried in the wings, even though the wings had the basic box-beam structure. It had 2° of freedom in the pitch and sideslip, whereas the rolls only had 1° of freedom.

Each engine contained a diverter valve. These valves either ducted longitudinally into the horizontal thrust nozzles of the aircraft, or inward to the lift nozzles located in the fuselage. The lift/cruise engines provided forward thrust when faced horizontally and lift when faced vertically. This was through the use of the diverter valves. All 6 tail pipes had 10° of freedom in order to direct thrust. The fuselage engines were used when initiating VTOL flight but were turned off when the aircraft was sufficiently in flight.

The XV-4B was faced with its fair share of electronic challenges, largely due to improper wiring. Otherwise the power system performed quite well, with a reduced number of electrical system components giving good reliability. One electronic stage was located at the end of the wiring sequence with the other at the opposite end in the electrohydraulic power actuators. Electrohydraulics simply replaced the hydraulically operated systems in the aircraft with purely electrical systems that do the same job. This reduced weight along with adding simplicity and reliability. It was driven by a set of two 300 amp generators powered by the engines. These fed 9 volt DC power into the main bussing and power distribution system.

Specifications (XV-4A)[]

Data from Lockheed Aircraft since 1913^[2]

General characteristics

Crew: 2
Length: 32 ft 8 in (9.96 m)

XV-4B 32.66 ft (10 m)

Wingspan: 25 ft 8 in (7.82 m)

XV-4B 25.66 ft (8 m)

Height: 11 ft 9 in (3.58 m)

XV-4B 12.25 ft (4 m)

Wing area: 104.00 sq ft (9.662 m²)
Empty weight: 4,995 lb (2,266 kg)

XV-4B 7,463 ft (2,275 m)

Gross weight: 7,200 lb (3,266 kg)

XV-4B 12,580 ft (3,834 m)

Powerplant: 2 × Pratt & Whitney JT12A-3LH turbojet, 3,300 lbf (15 kN) thrust each take-off thrust^[3]
Powerplant: 6 × General Electric J85-GE-19 turbojets, 3,015 lbf (13.41 kN) thrust each XV-4B only, 4 for lift,2 for horizontal flight

Performance

Maximum speed: 518 mph (833 km/h, 450 kn) at 10,000 ft (3,048 m)

XV-4B 463 mph (745 km/h)

Cruise speed: 390 mph (628 km/h, 339 kn)
Range: 600 mi (965 km, 521 nmi) normal
VTO range: 600 mi (966 km)
Rate of climb: 12,000 ft/min (61 m/s)
Wing loading: 69.2 lb/sq ft (338 kg/m²)
Thrust/weight: 1.176

XV-4B 1.43

Notes[]

^ ^a ^b "Hummingbird A Promising Augmented-Jet VTOL Aircraft" Flight International, 3 April 1962
^ Francillon, Rene J. (1988). Lockheed Aircraft since 1913 (Reprint ed.). London: Putnam & Company Ltd. pp. 432–434. ISBN 0-87021-897-2.
^ "The Engines of Pratt & Whitney:A Technical History" Jack Connors,published by AIAA, ISBN 978-1-60086-711-8, p. 287

References[]

X-Planes and Prototypes by Jim Winchester

External links[]

VSTOL.org Wheel

[flightint-1] "Hummingbird A Promising Augmented-Jet VTOL Aircraft" Flight International, 3 April 1962

[Franc-2] Francillon, Rene J. (1988). Lockheed Aircraft since 1913 (Reprint ed.). London: Putnam & Company Ltd. pp. 432–434. ISBN 0-87021-897-2.

[3] "The Engines of Pratt & Whitney:A Technical History" Jack Connors,published by AIAA, ISBN 978-1-60086-711-8, p. 287

[1]

[2]

[3]

v t United States STOL and VTOL aircraft designations
Original sequence (1954-1962)	V-1 V-2 V-3
Tri-service sequence (1962-present)	V-1 V-2 V-3 V-4 V-5 V-6 V-7 V-8 (I) V-8 (II) B V-9 V-10 V-11 V-12 (I) V-12 (II) V-13¹ V-14¹ V-15 V-16 V-17¹ V-18 V-19¹ V-20 V-21¹ V-22 V-23 V-24
¹ Not assigned